Bulbs
Flower Basics
Flower Beds & Specialty Gardens
Flower Garden
Garden Furniture
Garden Gnomes
Garden Seeds
Garden Sheds
Garden Statues
Garden Tools & Supplies
Gardening Basics
Green & Organic
Groundcovers & Vines
Growing Annuals
Growing Basil
Growing Beans
Growing Berries
Growing Blueberries
Growing Cactus
Growing Corn
Growing Cotton
Growing Edibles
Growing Flowers
Growing Garlic
Growing Grapes
Growing Grass
Growing Herbs
Growing Jasmine
Growing Mint
Growing Mushrooms
Orchids
Growing Peanuts
Growing Perennials
Growing Plants
Growing Rosemary
Growing Roses
Growing Strawberries
Growing Sunflowers
Growing Thyme
Growing Tomatoes
Growing Tulips
Growing Vegetables
Herb Basics
Herb Garden
Indoor Growing
Landscaping Basics
Landscaping Patios
Landscaping Plants
Landscaping Shrubs
Landscaping Trees
Landscaping Walks & Pathways
Lawn Basics
Lawn Maintenance
Lawn Mowers
Lawn Ornaments
Lawn Planting
Lawn Tools
Outdoor Growing
Overall Landscape Planning
Pests, Weeds & Problems
Plant Basics
Rock Garden
Rose Garden
Shrubs
Soil
Specialty Gardens
Trees
Vegetable Garden
Yard Maintenance
Why Does My Yard Machine Lawn Mower Idle Up & Down?
Why Does My Yard Machine Lawn Mower Idle Up & Down?. A Yard Machine lawn mower will idle at a constant speed, usually around 3,000 rpm, and shouldn't increase or decrease rapidly, especially when not under load. If it does, this usually occurs when the gas flow into the carburetor changes suddenly. Thoroughly inspect the entire fuel system, as the...
A Yard Machine lawn mower will idle at a constant speed, usually around 3,000 rpm, and shouldn't increase or decrease rapidly, especially when not under load. If it does, this usually occurs when the gas flow into the carburetor changes suddenly. Thoroughly inspect the entire fuel system, as the underlying problem may end up damaging more sensitive engine parts.
Gas Cap
The Yard Machine lawn mower's carburetor uses vacuum pressure to bring fuel from the tank into the carburetor. The diaphragm in the fuel pump pulses with the crankshaft and squeezes more fuel into the tank. However, the pressure inside the tank needs to be less than the pressure inside the carburetor for this process to work. When a fuel cap can't vent the pressurized gasses inside the carburetor, the engine may surge and eventually stop. Clean the gas cap's vent hole, in the center of the cap, or replace the fuel cap.
Plugged Fuel Filter
As the fuel flows from the tank to the carburetor, it must pass through a filtration system to get rid of any particles that might scour the bore inside the chamber. This filter, if partially clogged, will cause the engine to suffer idling problems. This occurs usually when a piece of grass or dirt got dropped into the fuel tank. As the object floats around inside the tank, it will eventually get sucked up against the filter. Clean the fuel filter after every 15 hours and replace it seasonally.
Dirty Fuel Hoses
After the fuel leaves the tank, it travels through the fuel hose to the carburetor, while any unused fuel from the last cycle gets dumped back into the fuel tank via the purge hose. If either of these hoses gets blocked, the result will be a drop in fuel that can cause the mower to suddenly idle up or down. These hoses can get clogged from debris that's small enough to pass through the filter. Impurities in the fuel will also eventually clog these hoses. Replace the fuel hoses every other season.
Carburetor Problems
When the fuel reaches the carburetor, an inlet needle opens a lever, allowing the fuel to pass through the main bore and jet. A partially clogged jet or bore will also cause idling problems, such as surges. The lever on the carburetor can also get stuck partially open, if the inlet needle gets stuck. When cleaning the rest of the fuel system can't solve the problem, take the carburetor out of the engine and disassemble it. Clean the inlet lever and needle with carburetor cleaner and make sure they get reseated properly during assembly.
